Product ID:ROYCO 481
MSDS Date:06/04/1997
FSC:9150
NIIN:00-231-6676
MSDS Number: BDLBQ

ROYAL LUBRICANTS COMPANY INC.

MERRY LN
EAST HANOVER, NJ 07936
US

Emergency Phone: 201-887-7410/800-424-9300(CHEMTREC)

Info Phone: 201-887-7410/201-887-8404

Cage: 07950

ROYAL LUBRICANTS COMPANY INC.

518 EAST HANOVER, NJ 07936 US

Telephone: 973-887-7411/7410

Cage: 07950

MINERAL OIL/HYDROTREATED LIGHT NAPHTHENIC DISTILLATE

CAS: 64742-53-6

RTECS: PY8036000

Fraction By Weight: 96 - 99%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

MINOR ADDITIVES

Fraction By Weight: <2%

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- LUBRICATING OILS ARE GENERALLY CONSIDERED NO
MORE THAN MINIMALLY IRRITATING TO EYES & SKIN. INHALATION OF VAPOR
(GENERATED AT HIGH TEMPERATURE S ONLY)/OIL MIST MAY CAUSE MILD
IRRITATION OF RESPIRATORY TRACT. ASPIRATION HAZARD IF SWALLOWED.
CHRONIC- DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, DERMATITIS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF
THIS PRODUCT.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. SKIN:WASH WITH PLENTY OF
SOAP & WATE R. ORAL:DO NOT INDUCE VOMITING. SEEK MEDICAL ATTENTION.
IF VOMITING OCCURS, KEEP HEAD BELOW HIPS. DO NOT GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.

Flash Point Method:COC
Flash Point:290F,143C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC GASES MAY BE FORMED.

Spill Release Procedures:PICK UP SPILL WITH INERT MATERIAL SUCH AS
SAND, CLAY, EARTH. SHOVEL INTO CONTAINERS FOR DISPOSAL. PREVENT
RUN-OFF TO ENTER WATERWAYS, SEWERS. THIS IS AN OIL. SPILLS INTO OR
LEADING TO SURFACE WATER TH AT CAUSE A SHEEN MUST BE REPORTED:
800-424-8802.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED PLACE
AWAY FROM STRONG OXIDIZERS. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN. WASH THOROUGHLY
AFTER HANDLING. LAUNDER CLOTHING BEFORE REUSE. AVOID INHALING
MISTS. DO NOT TAKE INTERNALLY.

Respiratory Protection:NONE NORMALLY REQUIRED. IF WORKING IN CONFINED
AREAS, IF EXCESSIVE MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES
EXCEED RECOMMENDED PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR
NIOSH-APPROVED ORGANIC VAPO R RESPIRATOR.
Ventilation:GENERAL ROOM VENTILATION SHOULD BE SUFFICIENT.
Protective Gloves:NITRILES IF PROLONGED/REPEATED CONTACT
Eye Protection:SAFETY GOGGLES IF SPLASHING ANTICIPATED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DISCARD CONTAMINATED LEATHER GLOVES AND
SHOES.
Supplemental Safety and Health
FORMULA CHANGED. NOTE TO PHYSICIAN: IF > 2 ML PER KG HAS BEEN INGESTED
AND VOMITING HAS NOT OCCURED, EMESIS SHOULD BE INDUCED WITH
SUPERVISION. KEEP VICTIM'S HEAD BELOW HIPS. IF SYMPTOMS SUCH AS
LOSS OF GAG REFLEX, CONVULSION/UNCONSCIOUSNESS OCCUR, GASTRIC
LAVAGE USING A CUFFED ENDOTRACHEAL TUBE SHOULD BE CONSIDERED.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>480F,>249C
Vapor Pres:<0.5 @ 68F
Vapor Density:>5
Spec Gravity:0.87
Viscosity:10.3 CS @100F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT YELLOW OIL - SLIGHT HYDROCARBON ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:FLAME, HEAT
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
COMPD. MAY FORM.

Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
INCINERATION OR REUSE IS RECOMMENDED. IT IS NOT HAZARDOUS WASTE BY
RCRA CRITERIA (40 CFR 261).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.